| Common Name: | ACTI-KLEAN |
| Manufacturer: | VIRGINIA KMP |
| MSDS Revision Date: | 7/1/2004 |
| Grainger Item Number(s): | 4E840, 5W402 |
| Manufacturer Model Number(s): | AK-1, AK5 |
MSDS Table of Contents
Click the desired link below to jump directly to that section in the MSDS.
ACTI-KLEAN
(REVISED JULY 2004)
MATERIAL SAFETY DATA SHEET
| SECTION I - COMPANY IDENTIFICATION |  |
PRODUCT: ACTI-KLEAN
MANUFACTURED BY:
VIRGINIA KMP CORPORATION
4100 PLATINUM WAY
DALLAS, TEXAS 75237
CAT. NO.: AK-1, AK-5, AK-55
TELEPHONE NUMBERS:
OFFICE: 1-(214) 330-7731
EMERGENCY ONLY: 1-(800) 424-9300
| SECTION II - HAZARDOUS INGREDIENTS | |
OSHA HAZARDOUS COMPONENTS EXPOSURE LIMITS: 8 HR. TWA
(29 CFR 1910.1200) OSHA PEL ACGIH TLV
ETHYLENE GLYCOL MONOBUTYL ETHER 25 PPM (SKIN) 25 PPM (SKIN)
(CAS# 111-76-2)
DODECYLBENZENE SULFONIC ACID NE NE
(CAS# 27176-87-0)
| SECTION III - HAZARDS IDENTIFICATIONS | |
EMERGENCY OVERVIEW:
WARNING!
EYE AND SKIN IRRITANT. HARMFUL IF SWALLOWED OR INHALED.
POTENTIAL HEALTH EFFECTS:
INHALATION:
INHALATION OF VAPORS IN HIGH CONCENTRATION MAY CAUSE HEADACHE, NAUSEA,
VOMITING.
EYE CONTACT: IRRITATION DEVELOPS IMMEDIATELY ON CONTACT.
SKIN CONTACT: IRRITATION DEVELOPS ON CONTACT.
INGESTION: HARMFUL IF SWALLOWED. MAY CAUSE HEADACHE, NAUSEA, VOMITING.
CHRONIC EFFECTS: NOT ESTABLISHED.
NOTE:
CARCINOGENICITY:
LISTED IN NTP?: NO
IARC?: NO
OSHA REGULATED?: NO
| SECTION IV - FIRST AID MEASURES | |
INHALATION:
REMOVE VICTIM TO FRESH AIR AND, IF NEEDED, IMMEDIATELY BEGIN ARTIFICIAL
RESPIRATION. GIVE OXYGEN IF BREATHING IS LABORED. GET EMERGENCY MEDICAL
HELP. CONTACT A PHYSICIAN IMMEDIATELY.
EYE CONTACT:
FLUSH EYES WITH WATER FOR 15 MINUTES. GET MEDICAL ATTENTION IF SYMPTOMS
DEVELOP AND PERSIST.
SKIN CONTACT:
FLUSH WITH WATER OR SOAP AND WATER FOR 15 MINUTES OR UNTIL ALL TRACES HAVE
BEEN REMOVED. SEEK MEDICAL ATTENTION IF SYMPTOMS DEVELOP AND PERSIST.
INGESTION:
DO NOT INDUCE VOMITING. RINSE MOUTH OUT WITH WATER. GET IMMEDIATE MEDICAL
ATTENTION.
| SECTION V - FIRE FIGHTING MEASURES | |
FLASHPOINT (TEST METHOD): NOT FLAMMABLE - AQUEOUS SOLUTION.
FLAMMABLE LIMITS: NA
LOWER: NA
UPPER: NA
AUTOIGNITION TEMPERATURE: NE
GENERAL HAZARD:
FIRE FIGHTING INSTRUCTIONS:
APPROACH FIRE FROM UPWIND SIDE. AVOID BREATHING SMOKE, FUMES, MIST, OR
VAPORS ON THE DOWNWIND SIDE. FIREFIGHTERS WEAR PROTECTIVE CLOTHING AND
SELF-CONTAINED BREATHING APPARATUS.
EXTINGUISHING MEDIA: DRY POWDER, CARBON DIOXIDE (CO2), WATER FOG OR SPRAY.
HAZARDOUS COMBUSTION PRODUCTS:
ACRID SMOKE, IRRITATING AND TOXIC FUMES OF SOx, H2S, POx.
| SECTION VI - ACCIDENTAL RELEASE MEASURES | |
LAND SPILL:
SMALL SPILLS:
FLUSH TO SEWER WITH LARGE AMOUNTS OF WATER. 10 PARTS WATER TO 1 PART
PRODUCT.
LARGE SPILLS:
PICK UP WITH ABSORBENT MEDIA, PLACE IN NON-LEAKING CONTAINERS FOR PROPER
DISPOSAL OR REUSE.
WATER SPILL:
NOTIFY PROPER AUTHORITIES. CLEAN UP LEAKS/SPILLS IMMEDIATELY TO PREVENT SOIL
OR WATER CONTAMINATION.
| SECTION VII - HANDLING AND STORAGE | |
HANDLING:
AVOID CONTACT WITH SKIN, EYES, AND CLOTHING. AFTER HANDLING THIS PRODUCT,
WASH HANDS BEFORE EATING, DRINKING, OR SMOKING. IF CONTACT OCCURS, REMOVE
CONTAMINATED CLOTHING. IF NEEDED, TAKE FIRST AID ACTION SHOWN IN SECTION IV.
LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
STORAGE: STORE AWAY FROM FOOD STUFFS.
| SECTION VIII - EXPOSURE CONTROLS/PERSONAL PROTECTION | |
ENGINEERING CONTROLS: LOCAL EXHAUST VENTILATION.
PERSONAL PROTECTION:
RESPIRATORY PROTECTION NOT NORMALLY NEEDED UNDER NORMAL CONDITIONS OF USE.
USE RUBBER OR LATEX GLOVES, CHEMICAL GOGGLES OR FULL FACE SHIELDS. USE
BOOTS, APRONS, DRENCH SHOWERS, EYE WASH AS NEEDED FOR PROTECTION AGAINST
SPILLS AND/OR SPLASHES.
| SECTION IX - PHYSICAL AND CHEMICAL PROPERTIES | |
VAPOR PRESSURE: ND
VAPOR DENSITY (AIR=1): ND
SPECIFIC GRAVITY (H2O=1): 1.02
EVAPORATION RATE (BuAc=1): <1
SOLUBILITY IN WATER: COMPLETE
VOC (G/L):
pH: 11-12
FREEZING POINT: ND
BOILING POINT: 212 F
APPEARANCE & ODOR: GREEN LIQUID.
| SECTION X - STABILITY AND REACTIVITY | |
STABILITY: STABLE.
CONDITIONS TO AVOID: HIGH TEMPERATURES.
MATERIALS TO AVOID: OXIDIZERS.
HAZARDOUS DECOMPOSITION PRODUCTS:
SOx, H2S, POx, AND FROM COMBUSTION - SMOKE AND TOXIC FUMES.
HAZARDOUS POLYMERIZATION: WILL NOT OCCUR.
| SECTION XI - TOXICOLOGICAL INFORMATION | |
ETHYLENE GLYCOLMONOBUTYLETHER:
TDLO: 600 MG/KG (ORAL - WMN)
TCLO: 195 PPM/8HR (INH - HUMAN) GIT
TCLO: 100 PPM (INH - HUMAN) NOSE, EYE, CNS
LD50: 470 MG/KG (ORAL - RAT)
LC50: 2900 MG/M3 (INH - RAT)
DODECYL BENZENE SULFONIC ACID:
LD50: 50-500 MG/KG (ORAL - MOUSE)
| SECTION XII - ECOLOGICAL INFORMATION | |
HARMFUL TO AQUATIC LIFE IN VERY LOW CONCENTRATIONS.
ETHYLENE GLYCOLMONOBUTYLETHER: 1000 PPM / 24 HR / BRINE SHRIMP / TLM
DODECYL BENZENE SULFONIC ACID: 5 - 15 PPM / GUPPY / LETHAL CONC.
| SECTION XIII - DISPOSAL CONSIDERATIONS | |
DISPOSE AS HAZARDOUS WASTE. CLASSIFICATION AND DOCUMENTATION IS REQUIRED
BEFORE DISPOSAL. FOLLOW ALL LOCAL, STATE AND FEDERAL REGULATIONS.
| SECTION XIV - TRANSPORTATION INFORMATION | |
PROPER SHIPPING NAME: NON-REGULATED MATERIAL, LIQUID
HAZARD CLASS:
IDENTIFICATION NUMBER:
DOT EMERGENCY GUIDE #:
REPORTABLE QUANTITY (RQ):
INTERNATIONAL: NON-REGULATED MATERIAL, LIQUID
| SECTION XV - REGULATORY INFORMATION | |
TSCA (TOXIC SUBSTANCE CONTROL ACT):
COMPONENTS OF THIS PRODUCT ARE LISTED ON THE TSCA INVENTORY.
CERCLA (COMPREHENSIVE ENVIRONMENTAL RESPONSE, COMPENSATION AND LIABILITY
ACT):
REPORTABLE QUANTITY IS 1000 LBS. (DODECYL BENZENE SULFONIC ACID). CONTACT
LOCAL AUTHORITIES FOR OTHER REPORTING REQUIREMENTS.
SARA TITLE III (SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT): NOT LISTED.
CALIFORNIA PROPOSITION 65: NOT LISTED.
| SECTION XVI - OTHER INFORMATION | |
STATE RIGHT-TO-KNOW PROGRAMS: MA, NJ, PA
NFPA RATINGS:
HEALTH 1
FLAMMABILITY 0
REACTIVITY 0
HMIS PROTECTIVE EQUIPMENT: X SEE YOUR SUPERVISOR
PREPARED BY: VIRGINIA KMP CORPORATION
THIS INFORMATION IS FURNISHED WITHOUT WARRANTY, EXPRESSED OR IMPLIED, EXCEPT
THAT IT IS ACCURATE TO THE BEST KNOWLEDGE OF VIRGINIA KMP. THE DATA ON THIS
SHEET RELATED ONLY TO SPECIFIC MATERIAL DESIGNATED HEREIN. VIRGINIA KMP
ASSUMES NO LEGAL RESPONSIBILITY FOR USE OR RELIANCE UPON THESE DATA.